Audi A3 8V 2.0 TDI 150bhp Known Faults

2013-201950,000–80,000 miles£400–£500

On quattro models, the Generation 5 Haldex unit frequently fails because VW/Audi removed the filter present on older generations.

Alternator / Smart Charge System Failure

2012-202070,000–120,000 miles£250–£450

Modern vehicles use smart charging systems to reduce engine load, but the complex regulators on the alternators frequently fail.

Starter Motor Solenoid / Brush Wear

2012-202070,000–130,000 miles£150–£350

The starter motor wears out internally. This is particularly common on vehicles equipped with Stop/Start systems.

Clutch Slave Cylinder / Concentric Bearing Leak

2012-202070,000–120,000 miles£400–£800

The concentric slave cylinder (CSC) inside the gearbox bellhousing fails, leaking hydraulic fluid and causing clutch failure.

Suspension Coil Spring Snapping

2012-202060,000–120,000 miles£150–£300

A very common MOT failure in the UK. Suspension coil springs corrode and snap, usually near the bottom pigtail.

DSG DQ250 Dual Mass Flywheel Wear

2013-201980,000–140,000 miles£700–£1000

The 6-speed wet DSG gearbox (DQ250) is highly reliable, but the Dual Mass Flywheel (DMF) attached to it is a consumable item that fails predictably.

Sticking Brake Calipers (Slider Pins Seized)

2012-202040,000–100,000 miles£80–£150

The floating brake caliper design relies on sliding pins. In the UK climate, salt and water ingress cause these pins to rust and seize solid.

Wheel Bearing Wear and Drone

2012-202050,000–110,000 miles£120–£250

Wheel bearing wear is a normal consumable on UK roads, but frequent pothole strikes accelerate the failure rate significantly.

Glow Plug Failure / Snapping in Head

2012-202060,000–110,000 miles£100–£300

Diesel glow plugs burn out over time causing cold starting issues. The major problem is they often snap in the cylinder head when mechanics try to remove them.

Shock Absorber Oil Leak and Failure

2012-202070,000–120,000 miles£200–£400

Shock absorbers lose their damping efficiency over time, and eventually blow their seals, leaking hydraulic fluid.

MMI Infotainment Screen Mechanism Failure

2013-201960,000–120,000 miles£150–£800

The pop-up MMI screen in the dashboard frequently gets stuck or stops working entirely due to a broken wiring ribbon or failed motor mechanism.

Air Conditioning Condenser Leak (Stone Damage)

2012-202040,000–120,000 miles£250–£450

The air conditioning condenser is mounted at the very front of the cooling pack, making it highly susceptible to stone damage from the road, leading to refrigerant loss.

Front Anti-Roll Bar Drop Link Wear

2012-202030,000–80,000 miles£60–£120

The front anti-roll bar drop links wear out on heavily potholed UK roads, causing an annoying knocking sound at low speeds.

Electric Window Regulator Cable Failure

2012-202050,000–120,000 miles£100–£200

The cables inside the electric window regulator mechanism fray and snap, causing the window glass to drop into the door frame.

Engine Thermostat Sticking Open

2012-202060,000–120,000 miles£100–£250

The engine coolant thermostat fails in the 'open' position. The engine never reaches its optimal operating temperature, killing fuel economy.

12V Battery Degradation and Failure