SevereAffected: 2004-201170,000–120,000 miles

Ford Focus Mk2 1.6 TDCi 110bhp — Alternator / Smart Charge System Failure

Modern vehicles use smart charging systems to reduce engine load, but the complex regulators on the alternators frequently fail.

Severity

Severe

DIY Difficulty

Moderate

Est. Cost

£250–£450

OBD Codes

P0620P0622

Component Diagram

Electrics

Typical layout and location for the Electrics assembly.

Reference Illustration

Symptoms

Red battery warning light on dashboard
'Charging System Fault' message
Systems shutting down (radio, power steering) as battery depletes
Car fails to start

Root Cause

The internal voltage regulator or diode pack on the alternator burns out due to heat and age. Occasionally, a slipping auxiliary belt causes the issue.

How To Fix

Test battery voltage with engine running (should be 13.8V - 14.7V).
If below 12.5V, replace the alternator.
Always replace the auxiliary drive belt at the same time.
Cost: £250-450

Estimated Repair Costs

Repair Option	Est. Cost (GBP)
DIY (parts only)	£100–£180
Independent Garage	£250–£450
Main Dealership	£400–£720

Other Faults on This Variant

EGR Valve Failure

Moderate

2005-201160,000–120,000 miles£80–£300

The EGR valve is a common failure on the 1.6 TDCi engine, causing power loss, rough idle, and excessive smoke.

Dual Mass Flywheel (DMF) Failure

Severe

2004-201180,000–150,000 miles£600–£1200

DMF failure is one of the most expensive known faults on the 1.6 TDCi. Typically requires replacement of flywheel and clutch together.

Turbocharger Failure

Severe

2004-2011100,000–180,000 miles£400–£900

Turbo failure on the 1.6 TDCi is common at higher mileages, often caused by oil starvation or sludge blockage.

Disclaimer: Repair cost estimates are indicative and based on community data. Always get a quote from a qualified mechanic before proceeding with any repair.