Volkswagen Golf Mk5 2.0 TDI 140bhp — Alternator / Smart Charge System Failure
Modern vehicles use smart charging systems to reduce engine load, but the complex regulators on the alternators frequently fail.
Severity
SevereDIY Difficulty
Moderate
Est. Cost
£250–£450
OBD Codes
P0620P0622Electrics
Typical layout and location for the Electrics assembly.
Symptoms
- Red battery warning light on dashboard
- 'Charging System Fault' message
- Systems shutting down (radio, power steering) as battery depletes
- Car fails to start
Root Cause
The internal voltage regulator or diode pack on the alternator burns out due to heat and age. Occasionally, a slipping auxiliary belt causes the issue.
How To Fix
- Test battery voltage with engine running (should be 13.8V - 14.7V).
- If below 12.5V, replace the alternator.
- Always replace the auxiliary drive belt at the same time.
- Cost: £250-450
Estimated Repair Costs
| Repair Option | Est. Cost (GBP) |
|---|---|
| DIY (parts only) | £100–£180 |
| Independent Garage | £250–£450 |
| Main Dealership | £400–£720 |
Other Faults on This Variant
High Pressure Fuel Pump Cam Follower Wear
CriticalThe PD (pumpe-düse) 2.0 TDI uses a mechanical cam follower to drive the high-pressure fuel pump. This follower wears rapidly and if not replaced destroys the camshaft — a £2,500 repair for a £15 part.
Dual Mass Flywheel Failure
SevereDMF failure on the Golf Mk5 2.0 TDI is a rite of passage for high-mileage cars. The flywheel absorbs diesel engine vibrations but wears out — often needing clutch replacement at the same time.
Gearbox Dogbone Mount Bush Failure
MinorThe lower engine pendulum mount (often called the dogbone mount) bushes perish, causing excessive engine movement, clunking, and sloppy gear changes.
Disclaimer: Repair cost estimates are indicative and based on community data. Always get a quote from a qualified mechanic before proceeding with any repair.