SevereAffected: 2006-201470,000–130,000 miles

Vauxhall Corsa Corsa D 1.3 CDTi 75bhp — Starter Motor Solenoid / Brush Wear

The starter motor wears out internally. This is particularly common on vehicles equipped with Stop/Start systems.

Severity

Severe

DIY Difficulty

Moderate

Est. Cost

£150–£350

OBD Codes

None

Symptoms

A single loud 'click' when turning the key, but engine doesn't crank
Engine cranks very slowly despite a fully charged battery
Whirring or grinding noise after the engine starts

Root Cause

The carbon brushes inside the motor wear down to the copper wiring, or the contacts inside the solenoid burn out from repeated arcing.

How To Fix

Confirm battery voltage is strong under load (to rule out a dead battery).
Replace the starter motor unit.
Ensure main earth straps from engine block to chassis are clean and tight.
Cost: £150-350

Estimated Repair Costs

Repair Option	Est. Cost (GBP)
DIY (parts only)	£60–£140
Independent Garage	£150–£350
Main Dealership	£240–£560

Other Faults on This Variant

EGR Valve Failure and Carbon Build-Up

Moderate

2006-201450,000–100,000 miles£80–£280

The Fiat/GM 1.3 CDTi is a capable diesel but its EGR valve blocks with carbon deposits regularly. This is one of the most common Corsa D complaints.

Diesel Particulate Filter Blockage

Moderate

2006-201440,000–90,000 miles£150–£800

DPF blockage is endemic on the 1.3 CDTi Corsa, largely because most owners use them for short trips where the DPF cannot self-clean.

EGR Valve Seized Open

Moderate

2006-201440,000–90,000 miles£150–£250

The EGR valve on the 1.3 CDTi clogs rapidly, usually jamming open and causing terrible starting and idling.

Disclaimer: Repair cost estimates are indicative and based on community data. Always get a quote from a qualified mechanic before proceeding with any repair.